Submit an Article
Become a reviewer
Vol 169
Pages:
116-119
Download volume:
Research article
Without section

Energy-saving technology of deep-rocked alumina production

Authors:
O. A. Dubovikov
About authors
  • G.V. Plekhanov Saint Petersburg Mining Institute
Date submitted:
2005-09-28
Date accepted:
2005-10-07
Date published:
2006-04-01

Abstract

A new energy-saving technology for the production of dead-burnt alumina has been studied, which differs from the existing ones in that the introduction of boric acid mineralizer simultaneously neutralizes the residual content of alkali. This makes it possible to carry out roasting in one stage. A method of chemical control over the content of α-modification of aluminum oxide during calcination of alumina has been proposed and tested. The method allows to monitor not only the quality of the obtained product, but also to quantify the content of corundum in alumina. The experimental results were confirmed by crystal-optical and X-ray diffraction studies.

Go to volume 169

References

  1. Арлюк Т.А. О дегидратации гидроокиси алюминия, отличающихся способом получения / Т.А.Арлюк, Г.В.Телятников // Цветные металлы. 1977. № 8. С.44-47.
  2. Гопиенко Г.Н. Влияние различных минерализаторов на образование α-Al2O3 из гидраргиллита и бемита / Г.Н.Гопиенко, Т.А.Заварницкая, Л.А.Пашкевич // Цветные металлы. 1970. № 4 .С.53-55.
  3. Гопиенко Г.Н. Изменение физико-химических свойств окиси алюминия при кальцинации гидраргиллита и бемита / Г.Н.Гопиенко, Т.А.Заварницкая, О.И.Аракелян // Цветные металлы. 1972. № 3. С. 29-30.
  4. Калинина А.М. О связи между структурой и характером термических превращений различных соединений окиси алюминия // Химия и технология глинозема: Тез. докл. Новосибирск, 1972. С.360-369.
  5. Калинина А.М. О полиморфизме и термических превращениях окиси алюминия // Материалы всес. совещания по химии и технологии глинозема: Тез. док. Новосибирск. 1960. С.5-14.
  6. Ткач О.Д. Влияние времени термообработки гидроокиси алюминия на поверхность получившихся активных окислов / О.Д.Ткач, В.В.Онуфриенок // ЖПХ. 1979. № 52. Вып.1. С.30-33.
  7. Роберт Б. Способ получения спеканием активной альфа-окиси алюминия / Пат.2235086. Франция. Приоритет ФРГ от 27.06.73. Кл. cosF 7/02. Заявл. 25.06.74. Опубл.28.02.75.

Similar articles

Elementary processes in precipitation of aluminum hydroxide
2006 V. N. Brichkin, A. V. Tsybizov, R. S. Gordeev
Improvement of designs of devices for combustion of natural gases of different composition
2006 P. V. Ivanov, Yu. V. Sharikov
Model of technology of limestone roasting in a shaft kiln
2006 I. N. Beloglazov, V. O. Golubev, O. V. Ziyazitdinova
Theoretical aspects of the phenomenon of intra-layer segregation
2006 A. M. Vasilev
Extraction of cerium(III) and yttrium(III) by carboxylic acids from nitrate media
2006 D. E. Chirkst, T. E. Litvinova, V. S. Starshinova, G. S. Roshchin, D. S. Lutskii
Study of the material composition of copper-nickel sulphide raw materials
2006 I. N. Beloglazov, G. I. Dolivo-Dobrovolskaya, S. N. Saltykova