Submit an Article
Become a reviewer
Abdalla M. Elbendari
Abdalla M. Elbendari
Postgraduate Student
Saint Petersburg Mining University
Postgraduate Student
Saint Petersburg Mining University
Saint Petersburg
Russia
N/A
Total cited
N/A
Hirsch index

Co-authors

Articles

Metallurgy and concentration
  • Date submitted
    2021-03-12
  • Date accepted
    2021-04-12
  • Date published
    2021-05-25

Increasing the efficiency of phosphate ore processing using flotation method

The paper presents flotation of two phosphate ore samples of different origin. Statistical analysis was used to study the effect of operating parameters on flotation efficiency. The paper proposes to increase the efficiency of flotation processing of magmatic phosphate ore with a low grade of the valuable component (P 2 O 5 = 10.88 %), containing nepheline and feldspars, by means of direct anionic flotation. Authors present an optimization of anionic flotation using tall oil fatty acids mixed with anionic phospholane as an anionic collector. The effect of adding soda ash to compensate for the influence of calcium cations on technological parameters of P 2 O 5 flotation was examined. The results of studying the flotation of nepheline ore (flotation tailings of magmatic phosphate ore) showed that replacement of phospholane with oxyethylated isotridecanol allowed to obtain a high-quality concentrate. It was estimated that with the addition of Na 2 CO 3 in the amount of 2,000 g/t, a concentrate was obtained with the grade and recovery of phosphorus pentoxide equal to 39.15 and 94.19 %, respectively. The paper proposes to increase the efficiency of flotation processing of sedimentary phosphate ore with a low grade of the valuable component (P 2 O 5 = 22.5 %), containing gypsum and quartz, by means of desliming followed by anionic or cationic reverse flotation. Tall oil fatty acid with anionic phospholane was used as a collector in anionic reverse flotation, and amine was used in cationic reverse flotation. Sodium tripolyphosphate was used as a P 2 O 5 depressant. It was found to be an effective depressant in both anionic and cationic flotation. When analyzing the statistical plan, it was estimated that the maximum grade of the valuable component in the concentrate (P 2 O 5 = 31.23 %) and the recovery to concentrate of 95.22 % were obtained in the chamber product at amine consumption of 950.88 g/t and sodium tripolyphosphate consumption of 500 g/t.

Read more
Tatyana N. Aleksandrova, Abdalla M. Elbendari (2021) Increasing the efficiency of phosphate ore processing using flotation method. Journal of Mining Institute. Vol 248. p. 260-271. DOI: 10.31897/PMI.2021.2.10